1、环氧沥青厚膜型涂料的用途Intended Uses用途用于船底,压载水舱,污水及其他恶劣环境中的钢铁长期保护,也适用于码头,石油,铁井平薹,港口闸门,矿井支架,管道等钢铁或混凝土等作防腐涂料,有优良的防腐性能,漆膜坚韧,物理机械性能佳,附着力强.Provide a long-term protection on ship bottom, ballast tank, sewage tank and other steel in severely corrosive conditions. It is also applied on steel or concrete of wharf, petr
2、oleum drilling platform, port, sluice gate , mine shaft support, pipe etc as anti-corrosive paint , It forms a tough coating with excellent corrosion resistance, physical and mechanical properties , good adhesion. ProductDescription产品简介底漆:棕色; 面漆:黑色, 双罐装,乙组份为底漆和面漆均通用的固化剂Primer: brown; Finish: black.
3、Two packages. Component B is universal curing agent for primer or finish.Volume Solids 固体份 65%Dry Film Thickness 干膜厚度125 microns equivalent to192 microns of wet film 125 微米相当于 192 微米湿膜厚Theoretical Coverage 理论涂布率 4.3m2 /Kg 4.3 平方米/公斤ProductInformation产品数据Practical Coverage 实际涂布率 Allow appropriate los
4、s 允许适量损耗Mix Radio 混合比 A : B=9:1(by weight) 甲:乙=9:1(重量比)Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Conventional Spray 传统喷涂 Not Recommended 不推荐采用Thinner 稀释剂 C003Cleaner 油漆设备清洗剂 C003Pot Life 使用期 25:6h (小时) 30:4h (小时) Storage 贮存期 One year 一年Over
5、coating Interval覆涂间隔Application Details施工详述Drying time 干燥时间SubstrateTemperature底材温度Touch Dry表干（h）Hard Dry硬干（h） Mix 最短 Max 最长 203042481642 hours 小时16 hours 小时5days (天)2days (天)Specific Gravity 比重 Approx 1.2Kg/L 大约 1.2 公斤/公升Pack size 包装规格 A;18Kg in 20 liter container 甲:18 公斤装于 20 公升容器中B:2Kg in 4 liter
6、 container 乙:2 公斤装于 4 公升容器中Storage andHandling贮存与管理 Flash Point 闪点 Primer(底漆): 22 Finish(面漆):21 Limitations限制 Recommend cost: Spray one coat of primer and one coat of finish with high-pressure ariless spray for sake of 250 microns of dry film thickness.Preceding coat: Epoxy zinc rich shop primer, ep
7、oxy zinc dust primer, inorganic zinc silicate primer, micaceous iron oxide epoxy anti-corrosion paint etc. Also be painted directly on surface treated to Sa2.5.推荐涂装道数：高压无空气喷涂底，面漆各一道，干膜厚度达到 250 微米。前道配套涂料：环氧富锌车间底漆，环氧锌粉底漆，无机硅酸锌底漆，环氧云铁防锈漆等等，也可直接在防锈质量达到 Sa2.5 级的钢材表面涂漆。The product must be used in painting
8、 area by professionals. When painting, please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.参 http:/The product is a kind of solvent-based paint. In order to avoid the
9、accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No stati
10、c electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg s
11、olvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,
12、If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended Safe
13、tyPrecautions安全措施to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective s
14、afety precautions (Refer to the specification), our company will NOT be responsible for any accident.本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)
15、。 施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的 10 %,通常每千克溶剂需要 200 立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10 %的工作环境。 采取有效措施，防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂彻底清洗；若眼睛受到污染,请即刻用清水冲洗至少 10 分钟,并立即就医。在施工时，建议佩戴面罩以免吸入漆雾和有害气体，尤其在通风不良的环境下，更要注意。最后请谨慎处理废旧漆桶以免污染环境。责任声明：对于未按本公司所要求采取有效得安全措施而引起的安全事故,本公司不负任何责任。来源：江苏纽克莱涂料有限公司官网 http:/www.nsk-
