1、氯化橡胶铝粉防锈漆Intended Uses用途适用于船底水线、水闸、水下钢结构、地下管道以及其他结构的防蚀，是一种屏蔽性较好的防锈漆，附着力强，具有干燥迅速，能在低温条件下施工的特性，并有良好的耐水性、防腐性、耐干湿交替。Suited for anti-corrosive protection of ship bottom, boot toppings, sluice gate, steel and iron structure under water, underground pipeline and other iron structures. With good barrier pro
2、perty. Excellent adhesion and quick dry. Available application at low temperature and good resistance to water, anti-corrosion and humid-dry cycling resistance. ProductDescription产品简介银灰色，铝粉防锈漆Appropriate silver , anti-corrosive paint Volume Solids 固体份 40%Dry Film Thickness 干膜厚度40 microns equivalent
3、to100 microns of wet film 40 微米相当于 100 微米湿膜厚Theoretical Coverage 理论涂布率 8.70 m2 /Kg 8.70 平方米/公斤ProductInformation产品数据Practical Coverage 实际涂布率 Allow appropriate loss 允许适量损耗Mix Radio 混合比 One package 单罐装Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Recommended 推荐采用
4、Conventional Spray 传统喷涂 Recommended 推荐采用Thinner 稀释剂 C001Cleaner 油漆设备清洗剂 C001Pot Life 使用期 Not limit 不限制Storage 贮存期 One year 一年Application Details施工详述Drying time Substrate Touch Hard Dry Over coating Interval 覆涂间隔Temperature 底材温度Dry表干（H）硬干(H） Mix 最短 Max 最长 干燥时间25 2 80 24 hour 小时24 8 hour 小时30 6 hour 小
5、时Not limit不限Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥Pack size 包装规格 A;15Kg in 20 liter container 甲:15 公斤装于 20 公升容器中B:5kg in 5 liter container 乙：5 公升装于 5 公升容器中Flash Point 闪点 33 Storage andHandling贮存与管理 Specific Gravity 比重 Approx1.06 Kg/L 大约 1.06 Kg/LSpecification and Surface preparation技术要求
6、及表面处理Steel surface to be painted should be shot or grit blasted to Swedish Sa2.5 or rust-removed manually with power tool to Swedish Standard St3施工钢材表面需经抛丸或喷砂处理去锈达瑞典标准 Sa2.5 级或手工、动力除锈达St3 级Limitations限制Preceding Coat: Epoxy Zinc-rich shop primer, Epoxy zinc dust shop primer, Epoxy iron-oxide red sho
7、p primer. Inorganic zinc silicate shop primer. Also directly coated on the rust-removed steel substrate.Subsequent coat: High-build chlorinated rubber iron-oxide red anti-corrisive paint, chlorinated rubber micaceous iron oxide anti-corrosive paint. High build chlorinated rubber finish, phenilic pai
8、nt for boot toppings etc.前道配套涂料：环氧富锌车间底漆、环氧铁红车间底漆、无机硅酸锌车间底漆、也可直接涂覆在经过除锈的钢材上。后道配套涂料：氯化橡胶铁红厚浆型防腐漆、氯化橡胶云铁防腐漆、氯化橡胶厚浆型面漆、酚醛水线漆等 SafetyPrecautions安全措施The product must be used in painting area by professionals. When painting , please be sure to refer to Product Data Sheet and MSDS. Consult our company if c
9、onsumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and
10、it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is nec
11、essary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to preve
12、nt skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoro
13、ughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more
14、necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident.本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用
15、本产品前,未能详细了解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)。施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的 10 %,通常每千克溶剂需要 200立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10 %的工作环境。 采取有效措施，防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂彻底清洗；若眼睛受到污染,请即刻用清水冲洗至少 10 分钟,并立即就医。来源 http:/www.nsk-
