1、卡特 C系列发动机故障代码表Flash Code SPN (1)/FMI Code Diagnostic Code or Event Code Description of Code 174-03 174-03 Fuel Temperature open/short to +batt 燃油温度传感器或线路故障13 174-04 174-04 Fuel Temperature short to ground 燃油温度传感器或线路故障626-05 2417-05 Ether Injection Control Solenoid open/short to +batt 乙醚喷射控制电磁阀或线路故障1
2、6 626-06 2417-06 Ether Injection Control Solenoid short to ground 乙醚喷射控制电磁阀或线路故障678-03 41-03 8 Volt DC Supply short to +batt 8V直流电源故障678-04 41-04 8 Volt DC Supply short to ground 8V直流电源故障620-03 1079-03 262-03 5 Volt Sensor DC Power Supply short to +batt 5V直流电源故障620-04 21 1079-04 262-04 5 Volt Sensor
3、 DC Power Supply short to ground 5V直流电源故障100-03 100-03 Engine Oil Pressure open/short to +batt 机油压力传感器或线路故障100-04 100-04 Engine Oil Pressure short to ground 机油压力传感器或线路故障24 100-10 100-10 Engine Oil Pressure abnormal rate of change 机油压力更新率不正常102-03 102-03 Boost Pressure Sensor short to +batt 增压压力传感器或线
4、路故障102-04 102-04 Boost Pressure Sensor short to ground 增压压力传感器或线路故障102-10 102-10 Boost Pressure Sensor abnormal rate of change 增压压力更新率不正常102-03 1785-03 Intake Manifold Pressure Sensor voltage above normal 进气压力传感器电压高于正常值102-04 1785-04 Intake Manifold Pressure Sensor voltage below normal 进气压力传感器电压低于正常
5、值25 102-10 1785-10 Intake Manifold Pressure Sensor abnormal rate of change 进气压力更新率不正常26 108-03 274-03 Atmospheric Pressure open/short to +batt 大气压力传感器或线路故障108-04 274-04 Atmospheric Pressure short to ground 大气压力传感器或线路故障110-03 110-03 Engine Coolant Temperature open/short to +batt 冷却液温度传感器或线路故障27 110-0
6、4 110-04 Engine Coolant Temperature short to ground 冷却液温度传感器或线路产28 91-13 91-13 Throttle Position calibration required 油门需要校准32 91-08 91-08 Throttle Position signal abnormal 油门信号不正常190-08 190-08 Engine Speed signal abnormal 发动机转速信号不正常34 723-08 342-08 Secondary Engine Speed signal abnormal 备用发动机转速信号不正
7、常190-15 E362 (1) Engine Overspeed Warning 发动机超速报警35 190-00 E362 (3) Engine Overspeed Shutdown 发动机超速停机37 94-03 94-03 Fuel Pressure open/short to +batt 燃油压力传感器或线路故障94-04 94-04 Fuel Pressure short to ground 燃油压力传感器或线路故障105-03 172-03 Intake Manifold Air Temp open/short to +batt 进气温度传感器或线路故障38 105-04 172
8、-04 Intake Manifold Air Temp short to ground 进气温度传感器或线路故障42 637-13 261-13 Engine Timing calibration required 发动机正时需校准100-17 E360 (1) Low Engine Oil Pressure Warning 机油压力低报警100-18 E360 (2) Low Engine Oil Pressure Derate 机油压力低降载46 100-01 E360 (3) Low Engine Oil Pressure Shutdown 机油压力低停机168-00 168-00 S
9、ystem Voltage high 系统电压高168-01 168-01 System Voltage low 系统电压低51 168-02 168-02 System Voltage intermittent/erratic 系统电压不正常56 630-02 268-02 Check Programmable Parameters 发动机参数设置需检查58 639-09 247-09 J1939 Data Link communications J1939数据链接故障110-15 E361 (1) High Engine Coolant Temperature Warning 冷却液温度高
10、报警110-16 E361 (2) High Engine Coolant Temperature Derate 冷却液温度高降载61 110-00 E361 (3) High Engine Coolant Temperature Shutdown 冷却液温度高停机111-17 E2143 (1) Low Engine Coolant Level Warning 冷却液位低报警111-18 E2143 (2) Low Engine Coolant Level Derate 冷却液位低降载62 111-01 E2143 (3) Low Engine Coolant Level Shutdown
11、冷却液位低停机63 94-15 E096 (1) High Fuel Pressure Warning 燃油压力高报警64 1636-15 E539 (1) High Inlet Air Temperature Warning 进气温度高报警1636-00 E539 (3) High Inlet Air Temperature Shutdown 进气温度高停机174-15 E363 (1) High Fuel Temperature Warning 燃油温度高报警174-16 E363 (2) High Fuel Temperature Derate 燃油温度高降载65 174-00 E363
12、 (3) High Fuel Temperature Shutdown 燃油温度高停机0441-15 E445 (1) High Auxiliary Temperature Warning 辅助温度高报警0441-16 E445 (2) High Auxiliary Temperature Derate 辅助温度高降载0441-00 E445 (3) High Auxiliary Temperature Shutdown 辅助温度高停机0441-03 1836-03 Auxiliary Temperature Sensor open/short to +batt 辅助温度传感器或线路故障67
13、0441-04 1836-04 Auxiliary Temperature Sensor short to ground 辅助温度传感器或线路故障68 1387-15 E443 (1) High Auxiliary Pressure Warning 辅助压力高报警1387-16 E443 (2) High Auxiliary Pressure Derate 辅助压力高降载1387-00 E443 (3) High Auxiliary Pressure Shutdown 辅助压力高停机1387-03 1835-03 Auxiliary Pressure Sensor open/short to
14、+batt 辅助压力传感器或线路故障1387-04 1835-04 Auxiliary Pressure Sensor short to ground 辅助压力传感器或线路故障651-05 001-05 Cylinder #1 Injector open circuit 1缸喷油器故障71 651-06 001-06 Cylinder #1 Injector short 1缸喷油器故障652-05 002-05 Cylinder #2 Injector open circuit 2缸喷油器故障72 652-06 002-06 Cylinder #2 Injector short 2缸喷油器故障
15、653-05 003-05 Cylinder #3 Injector open circuit 3缸喷油器故障73 653-06 003-06 Cylinder #3 Injector short 3缸喷油器故障654-05 004-05 Cylinder #4 Injector open circuit 4缸喷油器故障74 654-06 004-06 Cylinder #4 Injector short 4缸喷油器故障655-05 005-05 Cylinder #5 Injector open circuit 5缸喷油器故障75 655-06 005-06 Cylinder #5 Injector short 5缸喷油器故障656-05 006-05 Cylinder #6 Injector open circuit 6缸喷油器故障76 656-06 006-06 Cylinder #6 Injector short6缸喷油器故障
